Drew Callahan Drew Callahan · November 28, 2025
RV Water Heater Thermostat and Heating Element Replacement I’m standing in front of the water heater access panel on a Grand Design Solitude, and the owner just told me they haven’t had hot water for three weeks. Three weeks of cold showers, lukewarm rinses, and a growing sense that something inside this hybrid system has … Read more
Drew Callahan · November 28, 2025
RV Awning Fabric and Motor Replacement I paid $1,847 to a dealer once for what turned out to be a three-hour awning fabric and motor replacement on a Grand Design Solitude—labor charges that could have bought the parts twice over and paid for a couple nights’ camping. That bill taught me something hard: when you … Read more
Drew Callahan · November 27, 2025
RV Water Heater Thermostat and Heating Element Replacement Most Keystone Montana owners will ignore their water heater until it stops working, and by then they’ve already made the problem worse. Here’s what actually happens: the heating element corrodes silently, or the thermostat drifts so far out of calibration that it either locks the element on … Read more
Drew Callahan · November 27, 2025
RV Slide-Out Motor and Gear Replacement Is your Montana’s slide grinding partway out, then locking up? Or worse—stuck halfway extended at a campground with no dealer within 200 miles? I’ve been there, and I’ve watched plenty of owners panic and accept a $2,000+ service bill when the actual fix runs closer to $400 and an … Read more
Drew Callahan · November 26, 2025
RV Water Heater Thermostat and Heating Element Replacement I was three weeks into a solo desert run through Arizona when the water heater on my North Point quit cycling properly. Started with that annoying pattern—lukewarm for ten minutes, then scalding, then back to lukewarm again. I kept adjusting the dial thinking I’d just dialed it … Read more
Drew Callahan · November 26, 2025
RV Awning Fabric and Motor Replacement You’ll get two very different answers if you call a Keystone dealer’s service line about replacing your Montana’s awning fabric versus posting the same question in a full-time RV forum. The dealer will quote you $1,200–$1,800 plus a six-week wait for parts and labor. The forum will tell you … Read more
Drew Callahan · November 25, 2025
RV Awning Fabric and Motor Replacement Jayco North Point awnings sit in a dead zone: the fabric degrades faster than most travel trailers because the roller tube runs deeper into the sidewall, trapping heat and UV damage where you can’t see it coming. By the time you notice the motor grinding or the fabric starting … Read more
Drew Callahan · November 25, 2025
RV Slide-Out Motor and Gear Replacement Your Jayco North Point’s owner’s manual will tell you to contact an authorized dealer if the slide-out binds or won’t operate. What it won’t say: a dealer service write-up for a failed motor and worn gear assembly can run $1,500–$2,500 in labor alone, and by the time you get … Read more
Drew Callahan · November 24, 2025
RV Awning Fabric and Motor Replacement Most RV owners ignore their awning until it stops working, and by then it’s usually too late to salvage anything but the frame. I’ve walked through dozens of Rockwood and Flagstaff trailers where a $300 fabric replacement turned into a $1,200 full motor-and-hardware rebuild because someone waited until the … Read more
Drew Callahan · November 24, 2025
RV Slide-Out Motor and Gear Replacement Most RV owners assume their slide-out motor will fail gracefully—a little noise, maybe some hesitation, then a clean stop. That’s not how it works. What actually happens is the motor burns itself out fighting a misaligned rack or seized gears, and by the time you notice something’s wrong, you’ve … Read more
