Drew Callahan · November 25, 2025
RV Slide-Out Motor and Gear Replacement Your Jayco North Point’s owner’s manual will tell you to contact an authorized dealer if the slide-out binds or won’t operate. What it won’t say: a dealer service write-up for a failed motor and worn gear assembly can run $1,500–$2,500 in labor alone, and by the time you get … Read more
Drew Callahan · November 24, 2025
RV Awning Fabric and Motor Replacement Most RV owners ignore their awning until it stops working, and by then it’s usually too late to salvage anything but the frame. I’ve walked through dozens of Rockwood and Flagstaff trailers where a $300 fabric replacement turned into a $1,200 full motor-and-hardware rebuild because someone waited until the … Read more
Drew Callahan · November 24, 2025
RV Slide-Out Motor and Gear Replacement Most RV owners assume their slide-out motor will fail gracefully—a little noise, maybe some hesitation, then a clean stop. That’s not how it works. What actually happens is the motor burns itself out fighting a misaligned rack or seized gears, and by the time you notice something’s wrong, you’ve … Read more
Drew Callahan · November 24, 2025
RV Water Heater Thermostat and Heating Element Replacement I’ve got a small cardboard box wedged behind my tool cabinet in the cargo van — labeled in Sharpie with “Arctic Wolf repeats.” Inside are four heating elements and three thermostats, all Forest River originals. That box exists because the water heater on these rigs fails the … Read more
Drew Callahan · November 23, 2025
RV Water Heater Thermostat and Heating Element Replacement Ignore a failing water heater thermostat or heating element long enough, and you’ll be bathing in cold water while the system burns itself out trying to reach a temperature it can’t sense anymore. The stakes aren’t just comfort — a malfunctioning heating element pulling continuous power strains … Read more
Drew Callahan · November 23, 2025
RV Awning Fabric and Motor Replacement I’ve got a piece of sun-rotted fabric rolled up in my garage right now — pulled it off a 2016 Jayco last month. The UV damage is so severe the material splits if you flex it, and the motor that was supposed to retract it just grinds and quits … Read more
Drew Callahan · November 22, 2025
RV Water Heater Thermostat and Heating Element Replacement “Drew, my New Horizons water heater won’t heat past lukewarm, and the dealer quoted me $850 just to look at it. I pulled the access panel and it looks pretty straightforward—can I swap out the thermostat and element myself?” That’s the text I got last month from … Read more
Drew Callahan · November 22, 2025
RV Slide-Out Motor and Gear Replacement I’m lying on my back under the slide frame with my phone flashlight wedged between my teeth, watching the drive gear spin freely on a shaft that’s doing absolutely nothing to push the rack anymore. The motor’s still getting power — I tested continuity twice — but the internal … Read more
Drew Callahan · November 21, 2025
RV Awning Fabric and Motor Replacement A full awning replacement on a DRV Mobile Suite can run you $1,200 to $1,800 through a dealer — and that’s before labor. But here’s what the invoice won’t tell you: most of that cost isn’t about complexity, it’s about the shop markup on parts you can source yourself … Read more
Drew Callahan · November 21, 2025
DRV Mobile Suites Slide-Out Motor and Gear Replacement Most DRV Mobile Suites owners wait until their slide-out grinds to a halt before they even think about the motor and gear system underneath. By then, you’ve usually done damage—stripped teeth on the rack, a motor that’s burned itself out fighting metal-on-metal friction, or a gear assembly … Read more
