Drew Callahan · November 29, 2025
Fresh Water System Service and Cassette Toilet Maintenance I have a corroded quick-connect fitting sitting on my workbench right now — pulled it from a Revel I picked up last spring. It’s weeping just enough that the stain on the subfloor underneath tells the real story: nobody on that rig had checked the water system … Read more
Drew Callahan · November 28, 2025
RV Slide-Out Motor and Gear Replacement “Drew, my Solitude’s bedroom slide grinds halfway out and then just quits. Dealer wants eight hundred bucks just to look at it. Can I swap the motor myself, or am I going to crack the frame trying?” That’s the message I got from a fellow full-timer in Quartzsite last … Read more
Drew Callahan · November 28, 2025
RV Awning Fabric and Motor Replacement I paid $1,847 to a dealer once for what turned out to be a three-hour awning fabric and motor replacement on a Grand Design Solitude—labor charges that could have bought the parts twice over and paid for a couple nights’ camping. That bill taught me something hard: when you … Read more
Drew Callahan · November 27, 2025
RV Slide-Out Motor and Gear Replacement Is your Montana’s slide grinding partway out, then locking up? Or worse—stuck halfway extended at a campground with no dealer within 200 miles? I’ve been there, and I’ve watched plenty of owners panic and accept a $2,000+ service bill when the actual fix runs closer to $400 and an … Read more
Drew Callahan · November 26, 2025
RV Awning Fabric and Motor Replacement You’ll get two very different answers if you call a Keystone dealer’s service line about replacing your Montana’s awning fabric versus posting the same question in a full-time RV forum. The dealer will quote you $1,200–$1,800 plus a six-week wait for parts and labor. The forum will tell you … Read more
Drew Callahan · November 25, 2025
RV Awning Fabric and Motor Replacement Jayco North Point awnings sit in a dead zone: the fabric degrades faster than most travel trailers because the roller tube runs deeper into the sidewall, trapping heat and UV damage where you can’t see it coming. By the time you notice the motor grinding or the fabric starting … Read more
Drew Callahan · November 25, 2025
RV Slide-Out Motor and Gear Replacement Your Jayco North Point’s owner’s manual will tell you to contact an authorized dealer if the slide-out binds or won’t operate. What it won’t say: a dealer service write-up for a failed motor and worn gear assembly can run $1,500–$2,500 in labor alone, and by the time you get … Read more
Drew Callahan · November 24, 2025
RV Awning Fabric and Motor Replacement Most RV owners ignore their awning until it stops working, and by then it’s usually too late to salvage anything but the frame. I’ve walked through dozens of Rockwood and Flagstaff trailers where a $300 fabric replacement turned into a $1,200 full motor-and-hardware rebuild because someone waited until the … Read more
Drew Callahan · November 24, 2025
RV Slide-Out Motor and Gear Replacement Most RV owners assume their slide-out motor will fail gracefully—a little noise, maybe some hesitation, then a clean stop. That’s not how it works. What actually happens is the motor burns itself out fighting a misaligned rack or seized gears, and by the time you notice something’s wrong, you’ve … Read more
Drew Callahan · November 23, 2025
RV Awning Fabric and Motor Replacement I’ve got a piece of sun-rotted fabric rolled up in my garage right now — pulled it off a 2016 Jayco last month. The UV damage is so severe the material splits if you flex it, and the motor that was supposed to retract it just grinds and quits … Read more
